This article will hopefully give you some insight on how to adjust your fuel injection pump on 88-93 7.3L Non-Powerstroke, IDI. This will probably work the same way on a 6.9L Navistar(Ford) engine as well. To start off, I would recommend putting in a pyrometer gauge before doing any kind of performance upgrades. I would […]
There are three computer modules which coordinate to control the Ram power train. Engine Control Module (ECM) – On the left side of the engine behind the fuel filter Fuel Injection Pump Control Module (FPCM) – On top of the injection pump Powertrain control module (PCM) – bolted to the Ram firewall under the hood […]
PYRO: Temperatures will vary whenever the throttle is moved or the terrain changes. The peak number is the most important while towing, the ISB can be safely run up to 1450 for short bursts and 1350 all day long. This number is strongly affected by modifications weather it be Air flow or Fuel delivery. If […]
Symptom/Condition: The vehicle may not warm completely, especially in cold ambient temperatures. This condition may be due to a thermostat that is stuck in the partial open position by debris in the cooling system. NOTE: THE COOLING SYSTEM USED ON THE CUMMINS DIESEL ENGINE EQUIPPED VEHICLES PROVIDES THE CAPACITY AND PROTECTION OF THE HIGHER GVWR […]
For TPS adjustment, Joe G. suggested using a potentiometer in the ground circuit. I decided to try it and It really gives a much better range of adjustment than elongating holes in the TPS body. Here is a schematic drawing showing how to wire it. Using the above circuit, adjusting the potentiometer adds resistance to […]
(1) you need to disconnect both negative battery cables at both batteries. I used a 1/2 inch deep socket to remove the cables from the battery terminals. (2) Remove starter motor to get to CKP. The sensor is located on the driver’s side of the engine with the starter motor placed in front of it. […]
Post Your Successful Diesel Mods At Dieseldatabase
Have you completed a successful mod on your diesel truck? and did you take pictures and discovered tips that might help others? Your post is welcome here. All you have to do is register on this site. Then contact us via the the contact form on the ABOUT page (see menu), letting us know you […]