Post Your Successful Diesel Mods At Dieseldatabase

By Dean Isaacson | Published: 7 Mar 2011

Have you completed a successful mod on your diesel truck? and did you take pictures and discovered tips that might help others? Your post is welcome here. All you have to do is register on this site. Then contact us via the the contact form on the ABOUT page (see menu), letting us know you […]

Rotary Axis Supply Pump Installation 24V CTD

By Dean Isaacson | Published: 8 Nov 2010

[thanks to K-O Engineering] Click the link for the pdf version of the RASP installation manual for the 24V CTD motor. RASP installation manual

Glossary of Diesel Abbreviations

By dieselminded | Published: 23 Oct 2010

2WD Two Wheel Drive 4WD Four Wheel Drive AAMOF As A Matter Of Fact – used by many on mail lists and message boards ABS Anti-lock Brake System: Modulates braking pressure to control wheel lockup ACM Airbag Controller Module: monitors sensors and deploys airbag(s) in the event of an accident ACT Air Charge Temperature ACV […]

Crankshaft Position Sensor Replacement

By unknown | Published: 23 Oct 2010

(1) you need to disconnect both negative battery cables at both batteries. I used a 1/2 inch deep socket to remove the cables from the battery terminals. (2) Remove starter motor to get to CKP. The sensor is located on the driver’s side of the engine with the starter motor placed in front of it. […]

Anti-Freeze Replacement

By unknown | Published: 23 Oct 2010

From Steve St.Laurent : Here’s how I did mine and I got approximately 5.5 gallons into the system, first I opened the petcock on the radiator (turn it, then pull on it a little, turn, pull, turn, pull – until it starts draining), that will drain the fluid out of the overflow bottle, once the […]

Superchips 3705 Chart and Installation

By unknown | Published: 23 Oct 2010

My Glowplug Relay Bypass System

By dzljim | Published: 23 Oct 2010

There have been many threads on the glow plug relay bypass idea discussing how and when to turn off the relay, and even whether or not it is a good idea at all. I have come up with a combination of ideas that I feel is the best scenario. How the glow plugs work depends […]

Turbo Charger Swap Guide

By dieselminded | Published: 23 Oct 2010

Completion time : 1 Hour HX35 12 CM HX35-21CM The following guide details the swap out between a modified HX35 with a 21CM Housing to a HX35 With a 12 CM Housing. The work is being done on a 2002 CTD. After Removing the Air Filter and hose…. Step 1 : Disconnect the Inter Cooler […]

Stewart Warner B754 Gauge Pods Install Sheet

By unknown | Published: 10 Nov 2010

Click the link below for the pdf version of Stewart Warner B754 Gauge Pods Install Sheet Stewart Warner B754 Gauge Pods Install Sheet [thanks to Stewart Warner sw-performance.com used with permission]

Propane Kit Comparison

By dieselminded | Published: 23 Oct 2010

When Propane is added to the air intake usually the horn it ensures that all the Diesel is turned into Power. When propane is used properly, it will keep your engine cleaner with less carbon buildup and cleaner oil. Propane is a high-octane fuel and burns slower and longer therefore, propane will help diesel burn […]

Weekend On The Edge 2006

By Dean Isaacson | Published: 11 Nov 2010

You could title this: My travels with Lem – Part II. Here we are on the road to the Weekend on the Edge event hosted by Edge Products of Ogden, Utah. The race is at the Rocky Mountain Raceway in West Valley City, Utah. This photo was taken at a rest stop in Montana. Funny, […]

1999 24V Lift Pump Replacement

By Andy | Published: 23 Oct 2010

Procedures for a 1999 Ram NOTE: You may be able to improve this but this is exactly what we did and changed two pumps in less that two hours) TOOLS: 17 mm wrench & socket, 10 mm wrench & socket, 7/16 socket, 1/2 inch socket. Lay a non-conducting material over the battery posts (fender cover, […]

4 Inch Turbo-Back Kit Number 4005500

By unknown | Published: 9 Nov 2010

Click the link to view the instructions for Turbo-Back Kit #4005500 instructions for Turbo-Back Kit #4005500

Top 3 Floor Mats for your Diesel Truck

By Andy | Published: 26 Mar 2010

It doesn’t take long to figure out that not all floor mats and liners are the same. Some offer great protection from the elements such as mud, snow, grime and dust, while others offer almost none. If you work in construction or any kind of industry that leavers your boots a little muddy at the […]

Stewart Warner B756 Standard Tachometer Install Sheet

By unknown | Published: 10 Nov 2010

Click the link below for the pdf version of Stewart Warner B756 Standard Tachometer Install Sheet Stewart Warner B756 Standard Tachometer Install Sheet [thanks to Stewart Warner used with permission]

Service Record Spreadsheet

By unknown | Published: 10 Nov 2010

Click the link below for the Excel version of Service Record Spreadsheet Service Record Spreadsheet [thanks to WBUSA used with permission]