Post Your Successful Diesel Mods At Dieseldatabase

Have you completed a successful mod on your diesel truck? and did you take pictures and discovered tips that might help others? Your post is welcome here. All you have to do is register on this site. Then contact us via the the contact form on the ABOUT page (see menu), letting us know you […]

Pump Diagnosis

[Copyright Diesel Injection Service used with permission]

Bosch P7100 Fuel Pump Diagrams

Click on Image for a Larger View. Click on Image for a Larger View.

Turbo Silencer Ring

A silencer ring is a metal baffle placed into the turbocharger inlet to reduce whistle from the turbocharger. It is installed in Ram truck engines at the request of Chrysler. The silencer ring has no effect on engine output, EGT, or boost levels. Removal: Remove the flex hose from the front of the turbo that […]

Edge Power Comp Manual 24V CTD

[thanks to Edge] Click the link for the pdf version of the Edge Power Comp Manual for the 24V CTD motor. Edge Power Comp Manual

Detailed Dodge Diesel Oil Change

Supplies: 3 Gallons Oil; Mobil Delvac Super 1300 is what I use, I should probably be using the Synthetic stuff. But I don’t. Oil Filter; My Fleet Guard Filter supply was tapped out so I had to run to advanced auto and get a Purolator… $15 !! The Fleet Guard Filters can be had for […]

Dodge Cummins Ebrake ECM Hookup

Using the ECM to Control Non-Jacobs Exhaust Brakes You will need this pigtail to connect the brake wiring to the ECM. Cummins Part Number: 3824810 Connect the pigtail show above to pin 20 of the ECM Schematic for the Dodge/Jacobs e-brake system connected to the ECM You will need to adapt your e-brake installation to […]

Transmission Pan Installation Guide

DODGE #727-D TRANSMISSION PAN Please read these instructions and parts list completely before installing this new transmission pan. Consult your owner’s or shop manual for transmission fluid requirements. TOOLS REQUIRED 1/2 socket wrench and driver (for removing the old cover) 1/4 allen bit with a 3/8 ratchet drive (1/4 allen key is furnished) 3/16 allen […]

Clutch Replacement

Start inside the truck. With a Phillips remove the screws holding the shift boot and slide it up. Remove shifter with 3/4″ or 19mm wrench. Pop up transfer case shifter boot and remove bolt/s. Pull out rubber inserts in cupholders and remove bolt/s. Remove plastic shroud. Unbolt shifter boot. Unbolt shift tower carefully and tape […]

Turning Up a P7100 Pump

The steps for turning up a P7100 pump are: 1) Remove your AFC Housing 2) Mod Your Fuel Plate either slide it forward or purchase a cut one 3) Adjust the governor lever to contact the fuel plate 4) Crank the star Wheel Towards the motor 5) Slide The AFC housing all the way forward […]

Propane Kit Comparison

When Propane is added to the air intake usually the horn it ensures that all the Diesel is turned into Power. When propane is used properly, it will keep your engine cleaner with less carbon buildup and cleaner oil. Propane is a high-octane fuel and burns slower and longer therefore, propane will help diesel burn […]

24V Piston Specs

Descriptions Specifications Piston Skirt Diameter 101.864 – 101.88 mm / 4.0104 – 4.011 in Ring Grove Clearance Intermediate Oil Control     0.095 mm / 0.0037 in 0.085 mm / 0.0033 in Top Ring 0.35 – 0.45 mm / 0.014 – 0.0177 in Intermediate 0.85 – 1.15 mm / 0.0334 – 0.0452 in Oil Control […]

Fuel Filter Usage

Here’s a photo showing the condition of my original fuel filter after 24,000 miles – never been changed to this point since new: The photo is a bit misleading the overall condition of the old filter is actually not bad at all – lots whiter down in between the pleats than can be seen here, […]

Serpentine Belt Replacement

Work performed on a 2002 Time Of Completion : 30 Mins Here’s my belt @ 48,000 miles may want to check yours out Tools Required : 1/2 Inch Drive Ratchet & an 1/2 to 3/8 reducer Parts Required : Here’s the Gatorback belt $33.50 at AutoZone; this part Number is for Models with A/C This […]

Fast Idle Modification

This mod article will walk you through the steps of installing a Fast Idle Switch. Application: ’05 6.0 PSD with Torque Shift Transmission.   Tools Required: 10mm socket with extension and ratchet Wire striper, cutter, crimp tool At least 5 feet of wire (12-14 gauge, color is user defined) 2 sets of butt or spade […]

Stewart Warner B793 LED Light Kit Install Sheet

Click the link below for the pdf version of Stewart Warner B793 LED Light Kit Install Sheet Stewart Warner B793 LED Light Kit Install Sheet [thanks to Stewart Warner used with permission]