Post Your Successful Diesel Mods At Dieseldatabase

By Dean Isaacson | Published: 7 Mar 2011

Have you completed a successful mod on your diesel truck? and did you take pictures and discovered tips that might help others? Your post is welcome here. All you have to do is register on this site. Then contact us via the the contact form on the ABOUT page (see menu), letting us know you […]

Stewart Warner B752 Full Pillar Pod Install Sheet

By unknown | Published: 10 Nov 2010

Click the link below for the pdf version of Stewart Warner B752 Full Pillar Pod Install Sheet Stewart Warner B752 Full Pillar Pod Install Sheet [thanks to Stewart Warner used with permission]

Ford 7.3L Engine Removal – The REAL How To

By dzljim | Published: 23 Oct 2010

After replacing my rear axle cover due to rust through, I noticed severe rust on the engine oil pan. I’ve had experiences with rusted oil pans in the past and knew this had to be taken care of soon, or I’d be doing it in the middle of an Ohio winter. Early October, 2001, I […]

24V Transmission Band Adjustment

By dieselman | Published: 24 Oct 2010

One of the most frequent questions I get on the Cummins powered Dodge trucks is transmission related. The Dodge automatic tranny is very robust and does what it was intended to do very well. But given the reputation for massive torque that the Cummins engine provides, many times the transmission is asked to do far […]

Twin Turbos on a Powerstroke Diesel

By dzljim | Published: 24 Oct 2010

A big thanks goes to John Anderson for being the Pioneer on this type of project and sharing his project with all of us. In that same spirit, I threw some pics into a collage to be able to share what I can now, until I can do a formal write up for this site. […]

Anti-Freeze Replacement

By unknown | Published: 23 Oct 2010

From Steve St.Laurent : Here’s how I did mine and I got approximately 5.5 gallons into the system, first I opened the petcock on the radiator (turn it, then pull on it a little, turn, pull, turn, pull – until it starts draining), that will drain the fluid out of the overflow bottle, once the […]

Windshield Wiper Motor Replacement

By dieselminded | Published: 10 Nov 2010

[A] Gently pry up on the little tap this will release a small piece of metal that just slides under the gear. After clip is released you will have to pry the WSW bottom off the gear this is the bad part — took longer to get the WSW off the gear then it did […]

Repair Under Hood Weatherstripping

By John Donovan | Published: 10 Nov 2010

Tired of always finding the weather strip laying on top of the turbocharger in the engine compartment? A bead of silicone rubber RTV in the weatherstrip groove will keep the strip attached and eliminate the fire danger. Red RTV or high strength gray RTV is my favorite for this type of work. Black RTV would […]

1999 24V Lift Pump Replacement

By Andy | Published: 23 Oct 2010

Procedures for a 1999 Ram NOTE: You may be able to improve this but this is exactly what we did and changed two pumps in less that two hours) TOOLS: 17 mm wrench & socket, 10 mm wrench & socket, 7/16 socket, 1/2 inch socket. Lay a non-conducting material over the battery posts (fender cover, […]

Mixing Gasoline with Diesel Caution

By unknown | Published: 23 Oct 2010

At one time information was released suggesting that a small amount of gasoline mixed with diesel fuel for use in cold weather was an acceptable practice. This information was eventually retracted due to conditions that may result from such a mixture. First and foremost is a safety factor. The gasoline fumes from gasoline are very […]

Stewart Warner B764 Programmable Speedometer Install Sheet

By unknown | Published: 10 Nov 2010

Click the link below for the pdf version of Stewart Warner B764 Programmable Speedometer Install Sheet Stewart Warner B764 Programmable Speedometer Install Sheet [thanks to Stewart Warner used with permission]

Ford 7.3L Diesel Fuel Tank Vent Mod

By dzljim | Published: 23 Oct 2010

About one month after I completed the extraction and re-installation of the PSD from my truck, necessitated to replace a rusted out oil pan, I noticed diesel fuel on the floor of my garage under the rear of my truck.  Sure enough the steel rear fuel tank had also rusted through.  Why in the world […]

24V Piston Specs

By unknown | Published: 23 Oct 2010

Descriptions Specifications Piston Skirt Diameter 101.864 – 101.88 mm / 4.0104 – 4.011 in Ring Grove Clearance Intermediate Oil Control     0.095 mm / 0.0037 in 0.085 mm / 0.0033 in Top Ring 0.35 – 0.45 mm / 0.014 – 0.0177 in Intermediate 0.85 – 1.15 mm / 0.0334 – 0.0452 in Oil Control […]

Clutch Tips

By unknown | Published: 23 Oct 2010

Note: Tip 3 is the only one that applies to a Ram pickup TIPS FROM AUTOMOTIVE PRODUCTS, INC. Automotive Products, Inc., the supplier of the Pre- filled Hydraulic Clutch Actuator Assembly for the Dodge Ram (BR), the Dodge Dakota (AN), the Jeep Wrangler (TJ), and the Jeep Cherokee (XJ), has some valuable tips for Automotive […]

Cummins Valve Cover Replacement

By dieselminded | Published: 10 Nov 2010

Here’s the Stocker And here’s the Bombed Valve cover Available Here at the Database: check the marketplace :: Bob Wagner The only tools you’ll need is a 1/4 inch drive ratchet and a 10 MM socket Really clean up the stock valve cover you do not want anything to fall down in to the valves […]

Stewart Warner B759 LED Light Kit Install Sheet

By unknown | Published: 10 Nov 2010

Click the link below for the pdf version of Stewart Warner B759 LED Light Kit Install Sheet Stewart Warner B759 LED Light Kit Install Sheet [thanks to Stewart Warner used with permission]