Post Your Successful Diesel Mods At Dieseldatabase

By Dean Isaacson | Published: 7 Mar 2011

Have you completed a successful mod on your diesel truck? and did you take pictures and discovered tips that might help others? Your post is welcome here. All you have to do is register on this site. Then contact us via the the contact form on the ABOUT page (see menu), letting us know you […]

BHAF – Big Honking Air Filter

By dieselminded | Published: 23 Oct 2010

BHAF = Big Honking Air Filter This is a very easy mod and the benefits are great … Cooler Egts … Better flow … More Whistle !!! First remove the air intake line running from your factory Air box to your Turbo Then remove your air box … just pull straight up This area it […]

24V Cummins Fueling System Diagram

By Andy | Published: 22 Oct 2010

1998 CTD No Description 1 Fuel Transfer (Lift) Pump 2 Fuel Return Line (to Fuel Tank) 3 Fuel Supply Line (Low Pressure, to Engine) 4 Fuel Heater 5 Water-in-Fuel (WIF) Sensor 6 Fuel Filter / Water Separator 7 IAT Sensor 8 Map (Boost) Sensor 9 Fuel Drain Manifold 10 CKP Sensor 11 CMP Sensor 12 […]

Two Wheel Drive Low

By Andy | Published: 24 Oct 2010

The important thing is the 2 port vacuum switch…you need to get one that is ‘open’ when it’s in the off position so vacuum can flow through normally. I used a Nippondenso EGR vacuum switch for a Honda Civic. They never break! The rest of the parts list is simple and small: Rocker switch (I […]

A Good Chain Can Make All The Difference

By Dean Isaacson | Published: 23 Oct 2010

I cannot describe the feeling but I know you’ve felt it before. The feeling you get when you know something is enormously wrong but just before the full impact hits you. It was only five fifteen but it was dark outside. I stepped outside my truck and was looking back at the trailer. From where […]

Ford 7.3L Diesel Fuel Tank Vent Mod

By dzljim | Published: 23 Oct 2010

About one month after I completed the extraction and re-installation of the PSD from my truck, necessitated to replace a rusted out oil pan, I noticed diesel fuel on the floor of my garage under the rear of my truck.  Sure enough the steel rear fuel tank had also rusted through.  Why in the world […]

A Recommendation for Trailer Pullers

By Wes Bailor | Published: 23 Oct 2010

I pull a 27 foot fifth-wheel RV trailer. I’ve had it all over the West. As you know, there is a hill or two out here. In fact just south of my town, Bend, Oregon, there is a grade that slowed my previous truck with this trailer to 45 mph top speed. I’ve always hated […]

Dodge Cummins Fan Removal

By unknown | Published: 23 Oct 2010

The thread is left hand; from the front of the engine you turn the wrench to the right (toward the driver side). Do this when the engine is cool. Some people pull the entire fan/hub assembly out past the radiator shroud, others remove the fan first, then remove the hub. In many cases, a drift […]

Dodge Towing Specifications

By unknown | Published: 23 Oct 2010

When Equipped with Cummins Turbo Diesel Dodge RAM 2500 RAM 2500 Reg Cab 4×2 Long Bed Quad Cab 4×2 Short Bed Quad Cab 4×2 Long Bed Trans/Axle GCWR Payload Curb Wt Tow Wt Payload Curb Wt Tow Wt Payload Curb Wt Tow Wt A4/3.55 16,000 3,120 5,679 10,150 2,820 5,981 9,850 2,700 6,096 9,750 A4/4.10 […]

Pump Diagnosis

By Andy | Published: 23 Oct 2010

[Copyright Diesel Injection Service used with permission]

Dodge Diesel Drive Belt Diagram

By unknown | Published: 23 Oct 2010

Location Description 1 Water Pump 2 Belt 3 Tensioner 4 3/8 Hole For Working Tensioner 5 Mount Bolt [thanks to BH used with permission]

Dodge 24V Diesel Dimensions & Specs

By unknown | Published: 23 Oct 2010

Descriptions Specification Engine Type In-Line 6 Cyl. Turbo Diesel Bore & Stroke 102.0 X 120.0 mm / 4.02 X 4.27 In. Displacement 5.9 L / 359 Cu. In. Compression Ratio 245 HP 2002 CTD 235 HP 2002 CTD   17.0:1 16.3:1 Horsepower A/T M/T   235 @ 2700 RPM 245 @ 2700 RPM Torque Rating […]

Turbo Charger Swap Guide

By dieselminded | Published: 23 Oct 2010

Completion time : 1 Hour HX35 12 CM HX35-21CM The following guide details the swap out between a modified HX35 with a 21CM Housing to a HX35 With a 12 CM Housing. The work is being done on a 2002 CTD. After Removing the Air Filter and hose…. Step 1 : Disconnect the Inter Cooler […]

24V Transmission Pan Comparisons

By dieselminded | Published: 24 Oct 2010

By adding an increased capacity transmission pan you decrease your fluid temperature and prolong the life of your transmission. Here are some options: Hughes (www.hughesperformance.com) Bolt on deep transmission pans are made from cast aluminum and designed with cooling fins to dissipate heat quicker. Cast aluminum pans hold approximately 2 to 4 extra quarts of […]

Adjusting Rear Drum Brakes

By unknown | Published: 23 Oct 2010

For trucks equipped with drum brakes there are a multiple of ways to adjust them. You should be able to get them to adjust automatically by using one of the procedures below. None of them work on my truck and I have to adjust mine manually. I even put all new hardware kits on and […]

Turning up the Injector Pump on a 7.3L or 6.9L IDI

By Andy | Published: 24 Oct 2010

This article will hopefully give you some insight on how to adjust your fuel injection pump on 88-93  7.3L Non-Powerstroke, IDI. This will probably work the same way on a 6.9L Navistar(Ford) engine as well. To start off, I would recommend putting in a pyrometer gauge before doing any kind of performance upgrades. I would […]